• TEL: 0086-21-58386256

use of crushed granite fine as a replacement to river sand in production of concrete

  • Partial Replacement of Sand with Quarry Dust in Concrete

    -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.[...]

  • Use of Crushed Granite Fine as Replacement to River Sand ...

    Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production . By Manasseh JOEL. Abstract. ... with the partial replacement of river sand with 20% CGF, as against values of 35.00N/mm2 and 1.75N/mm2, obtained with the use of river sand as fine aggregate. Based on economic analysis and results of tests, river sand replaced with ...[...]

  • Use of Crushed Granite Fine as Replacement to River Sand ...

    Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production Manasseh JOEL 86 Introduction Concrete is an artificial conglomerate stone made essentially of Portland cement, water, sand and coarse aggregates. The mixture of the materials results in a chemical reaction[...]

  • Partial Replacement of Coarse aggregate by Crushed Tiles ...

    30%. The fine and coarse aggregates were replaced individually by these crushed tiles and granite powder and also in combinations that is replacement of coarse and fine aggregates at a time in single mix. For analyzing the suitability of these crushed waste tiles and granite powder in the concrete mix,[...]

  • Quarry Mud as Partial Replacement for Fine Combination ...

    several trials to use ash academic degree industrial by product as partial r, e-placement for cement to possess higher workability, future strength and to make the concrete lots of economically accessible. This gift work could be a trial to use Quarry mud as partial replacement for sand in concrete. alsTriare[...]

  • Experimental study of concrete made with granite and iron ...

    The concrete mix made using granite powder (GP) and iron powder (IP) as partial replacement of sand showed good workability and fluidity similar to normal concrete mixes. 2. The compressive strength of concrete increased with the addition of granite powder (GP) as partial replacement of sand.[...]

  • Effect of replacement of natural sand by manufactured sand ...

    properties. Hudson, 1997: has taken a review of various tests in his article manufactured sand for concrete. Ilangovan et al., 2006: studies the strength and behavior of concrete by using crushed rock dust as fine aggregate, they investigated the possibility of using crushed rock as 100 % replacement for sand, with varying compacting factors.[...]

  • Experimental datasets on properties of river sand as an ...

    Aug 28, 2018· The data explored the assessment of the quality of river sand as an aggregate in replacement of crushed stones which are widely used by majority of manufacturers in production of interlocking stones. Experimental tests carried out on river sand and crushed rock as aggregates include: Grain size ...[...]

  • Experimental Investigation on the Effect of Replacement of ...

    obtained with the partial replacement of river sand with 20% CGF, as against values of 35.00N/mm2 and 1.75N/mm2 obtained with the use of river sand as fine aggregate. Based Experimental Investigation on the Effect of Replacement of Sand by Quarry Dust in Hollow Concrete …[...]

  • PARTIAL REPLACEMENT OF NATURAL RIVER SAND WITH …

    The use of crushed rock sand as a partial replacement of river sand in concrete production was and 0.59 for 0 % to 100 % natural sand replacement. The slump ranged between 49 and 60 mm for 0 % to 100 % natural sand replacement. N/mm2. The effective natural sand (RS) replacement ranged between 0 and 60 % with the best results achieved at 20 %[...]

  • Use of Crushed Granite Fine as Replacement to River Sand ...

    The suitability of Crushed granite fine (CGF) to replace river sand in concrete production for use in rigid pavement was investigated. Slump, compressive and indirect tensile strength tests were ...[...]

  • Aggregates for Concrete - GreenSpec

    • 'Aggregate' is a term for any particulate material. It includes gravel, crushed stone, sand, slag, recycled concrete and geosynthetic aggregates. Aggregate may be natural, manufactured or recycled. • Aggregates make up some 60 -80% of the concrete mix. They provide compressive strength and bulk to concrete.[...]

  • journals for crushed sand in concrete

    Use of Crushed Granite Fine as Replacement to River Sand, Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production, Utilization of Quarry Waste Fine Aggregate in Concrete Mixtures, Journal of Applied Sciences Research, Insinet Publication, 2007, 3(3), p 202-208 7 Murdock LJ, Brook KM, Dewar JD, Concrete Materials and ...[...]

  • project investigation of crushed rock powder concrete ...

    The study investigates the use of crushed rock sand as viable alternative to Natural River sand that is being conventionally used as fine aggregate in cement concrete. Various mix designs were developed for different grades of concrete based on IS, ACI and British codes using Natural River sand and crushed rock sand. read more[...]

  • COST EFFECTIVENESS OF REPLACING SAND WITH …

    Cost Effectiveness of Replacing Sand with Crushed Granite Fine (CGF) In the Mixed Design of Concrete Engr. Muritala Ashola ADIGUN, B.Eng; M.Sc Civil Engineering Department, Lagos State Polytechnic, Ikorodu, Lagos State, Nigeria. Abstract: The economic gain of replacing sand with Crushed Granite Fines in the production of concrete was investigated.[...]

  • Decomposed Granite Paving - Landscaping Network

    Decomposed granite, or DG, is made up of granite aggregates a 1/4" or smaller. Sometimes DG is so fine that it resembles sand. Decomposed granite is the least expensive way to pave a patio, walkway, or driveway.DG provides a natural, rustic look and is available in subtle hues of gray, tan and brown.[...]

  • Replacement of Natural Sand with Efficient Alternatives ...

    production. River Sand used as fine aggregate in concrete is derived from river banks. River sand has ... formed in the processing of the granite stones which broken downs into the coarse aggregates of different ... for the use of ground glass as a concrete replacement. (M. …[...]

  • River Sand Substitutes -An Overview - The Masterbuilder

    River Sand Substitutes. Sand Researchers world over are in continuous search for the alternatives to sand. Fine aggregate is one of the important constituents of concrete and mortar in construction industry. River sand is becoming a scarce material. Sand mining from our rivers has become objectionably excessive.[...]

  • replacement of river sand by crushed sand

    PARTIAL REPLACEMENT OF NATURAL RIVER SAND WITH . The use of crushed rock sand as a partial replacement of river sand in concrete production was and 0.59 for 0 % to 100 % natural sand replacement. The slump ranged between 49 and 60 mm for 0 % to 100 % natural sand replacement…[...]

  • New type of crushed sand to replace natural sand in ...

    Feb 04, 2015· New type of crushed sand to replace natural sand in concrete production. The availability of natural sand for concrete production is facing challenges, while the so-called waste stockpiles at aggregate crushing areas are causing problems for producers.[...]

  • Use of Quarry Dust to Replace Sand in Concrete – An ...

    as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water.[...]

  • An Investigation into the Use of Manufactured Sand as a ...

    Jun 02, 2016· Many studies have examined the influence of the partial replacement of fine aggregate in concrete using crusher dusts or small crushed sand samples on concrete properties [8,12,13]. However, little work has been performed on the complete replacement of natural fine aggregate in concrete with crusher dusts.[...]

  • (PDF) Replacement of Fine Aggregate with Local available ...

    He concluded that the properties of local soil is as good s the regular river sand and the investigation has proved that it can as well be used as fine aggregate in the production of concrete in lieu of river sand because its availability now a days has become scarce and also expensive.[...]

  • use of crushed stone dust in concrete

    2017-8-24 · Quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement (Balamurgan et al., 2013). While using crushed stone dust as fine aggregate in concrete it is found that there is increase in compressive, flexural and tensile strength of concrete (Nagpal et al ...[...]

  • Strength and durability aspects of partial replacement of ...

    Aug 29, 2016· Manasseh JOEL, "Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production", Leonardo Electronic Journal of Practices and Technologies ISSN 1583-1078 Issue 17, July- December 2010 p. 85-96. [4] S. AltafHussain, P. Shirisha, T. Shanti Kumar, S. Vamshi Krishna, Suggala. V.[...]

  • Use of Crushed Granite Fine as Replacement to River Sand ...

    Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production . By Manasseh JOEL. Abstract. The suitability of Crushed granite fine (CGF) to replace river sand in concrete production for use in rigid pavement was investigated. Slump, compressive and indirect tensile strength tests were performed on fresh and hardened concrete ...[...]

  • river sand used in concrete - afrikaanderplein.nl

    Use of Crushed Granite Fine as Replacement to River Sand . Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production . Manasseh JOEL . Naturally occurring clean sand used was obtained from River Benue and CGF was obtained from the quarry site at …[...]

  • Behaviour of Concrete on Replacement of Sand with Quaries ...

    3. Santhosh Kumar.P.T et al made an attempt to study the effect of type of fine aggregate on the 28 day compressive strength of concrete. The result of the investigation indicate that the ratio of the 28 day compressive strength of concrete with crushed stone sand to that of river sand is 1.06 with a coefficient of variation of 11 %.[...]

  • COMPRESSIVE STRENGTH OF CONCRETE USING …

    lateritic sand and quarry dust as complete replacement for conventional river sand fine aggregate. Samples of concrete (eg. cubes) were made using varying contents of laterite and quarry dust as ...[...]

  • joel m. (2009). use of crushed granite fine as replacement ...

    the using quarry dust as a replacement in concrete work | Clinker …. Use of Crushed Granite Fine as Replacement to River …River Sand in …Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production . Manasseh JOEL … »More detailed[...]